Commercial Tar and Gravel Flat Roof Leak Repair Edmonton, November 2015

Below you will find a routine leak repair service call for a commercial client by our Edmonton roofing repair crew. The following reports underline some of the work we do with other contractors and trades, such as plumbers.  Inspection, November 19 2015: We began to sweep the rock layer on the flat roof to expose the surface so that we could start looking for leaks. After speaking with the building manager, our crew has been asked to wait for a plumber before we inspect the drains. The second part of our inspection entails what units need to be removed.
20151119_144439
The client was the owner of a multi-residential apartment unit.
20151119_135416
We started by sweeping away rocks on the flat roof to look for the potential causes of water that was leaking into the building.
20151119_135419 Roof Report, November 21 2015: Today the crew removed more gravel from the roof. A couple leaks were patched up. The site manager gave us the go-ahead to remove one unit from the roof. Roof Report, November 23 2015: Today we shoveled more rock from the roof to find more holes that needed patching. Once it started snowing, we covered the roof and shut down the site.
20151123_120414
We eventually found a few holes throughout the roof that needed patching.
Roof Report, November 25 2015: We removed the one unit that the building manager had requested to be taken off-site. We also started working on two drains but were later informed that the owners were having all the pipes replaced, including on the other two drains that we were not given permission to begin work on. The remaining two pipes were added to the work order and we will have to wait until they have completed the pipe replacement before proceedings.
20151125_152201
We removed a unit off-site at the building manager's request and patched over it.
Roof Report, November 26 2015: We are still waiting for the plumber so that we can proceed with the inspection and maintenance on the remaining two drains. This site should be completed on Saturday. Site Completion, November 30 2015: We finished the site today, on schedule. The remaining two drains were replaced, which we had to add to the original work order. Another possible leak location was sealed. As well, any metal that we removed from the walls was reinstalled. Another rooftop unit was disposed of, as well.
20151130_111709
First drain replacement, with coatings around the seams.
20151130_143502
We then sealed in the second newly installed drain pipe.
20151130_143609
After sealing a final possible leak location, we reinstalled the cap flashing that we had previously removed.
< End Report > CODE: 106A Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.

Edmonton Rooftop Balcony Leak Repair, July 2015

Rooftop Balcony Leak Repair Edmonton - Below you will find a series of ongoing reports for a residential client in Edmonton, Alberta. The client requires leak maintenance where a PVC rooftop deck and a tar and gravel flat roof connect and flat roof recovery or replacement to the tar and gravel flat roof. Project manager notes have also been included.  This single family home in Edmonton Alberta has a second story rooftop deck (a deck that is over a heated living space is considered a rooftop deck - it needs a membrane suitable for over heated living spaces such as a flat roof membrane). It issue is the homeowners recently purchased the home and came to realize the second story balcony was leaking in to the home causing significant damage. So they hired a deck company to replace the membrane on the deck, but the decking company could not re-connect the balcony membrane to the tar and gravel roof that runs around the house as a skirt. The home-owner asked us to inspect the tar and gravel flat roof skirt and the need for the rooftop deck membrane to be connected properly (the deck membrane that was recently installed is a PVC and the PVC will not of course bond to a tar and gravel roof so a break needs to be constructed and then both the PVC deck membrane and the tar and gravel roof need to be tied in correctly). They also asked us to inspect the tar and gravel flat roof on top of the house. Update (07-30-2015): More posts to come as the work continues at this site. Update (07-30-2015): Quotation added New Client Call, July 24 2015:
  • Service: Roofing
  • Type: Residential flat roof
  • We have small issue with the roof section that joins up with the deck. There is water infiltration culminating in leaks.
Background The client purchased their home a few years ago; it is two storeys. The second story has a walk-out balcony over a heated living space. The balcony itself connected to a tar and gravel roof skirt that goes around the house. The balcony membrane was in a failed condition, so they had it replaced with a "vinyl" deck membrane not long ago. An inspection will also be required for the tar and gravel flat roof on the main roof. Concerns:
  1. The flat roof skirt that wraps the house which connects to the vinyl deck needs an assessment for replacement options.
  2. Most recently, there was a water ingress as the previous decking contractor did not correctly set a temporary waterproof scenario where the deck meets the flat roof skirt. An infrared technologist was called in and said there is no considerable issues in the walls, but considering the flat roof skirt's age there may be an issue with rotting joists or sheathing.
  3. An inspection is required on the connection area between the vinyl deck and the flat roof skirt. Is there a suitable break between the two sections appropriate for us to roof in the skirt properly?
  4. Inspect the main flat roof above for any maintenance concerns and estimate the expected life-cycle for future replacement considerations.
  5. Ask the client for the manufacturer name of the vinyl used for the most recent roof/deck replacement. When a roof deck is installed over a heated living space, there needs to be a product that is intended not only for use as a deck membrane, but also as a rooftop (low slope) roof membrane.
Assessment, July 25 2015: We arrived on-site at 1:00 pm and the client asked how much it would cost for us to only tie-in the new DuraDek material to the little roof that goes around the house as well as both ends where the deck and roof meets. The roof itself is a BUR roof and it was leaking into the house on the left side. The other end is fine, but the client wants some tie-in maintenance done there as well. We also did a main roof inspection for completeness.
Tar and gravel flat roof repair inspection Edmonton.
Upper tar and gravel flat roof that did not required repairs at this time.
Tar and gravel flat roof drawing.
Drawing from flat roof repair tech of tar and gravel flat roof skirt that needs replacement and upper tar and gravel flat roof.
Temporary waterproofing homeowner has at connection between PVC rooftop deck and tar and gravel flat roof.
Temporary waterproofing homeowner has at connection between PVC rooftop deck and tar and gravel flat roof.
Tar and gravel flat roof skirt that goes around house.
Tar and gravel flat roof skirt that goes around house.
Tar and gravel flat roof that needs to be replaced.
Tar and gravel flat roof that needs to be replaced.
Other end of tar and gravel flat roof that needs to be replaced - it connects to the rooftop deck that has the PVC membrane installed.
Other end of tar and gravel flat roof that needs to be replaced - it connects to the rooftop deck that has the PVC membrane installed.
This is a photo of the upper tar and gravel flat roof that was inspected that does not require repair, maintenance or replacement at this time.
This is a photo of the upper tar and gravel flat roof that was inspected that does not require repair, maintenance or replacement at this time.
Temporary waterproofing between PVC deck membrane and flat roof.
Temporary waterproofing between PVC deck membrane and flat roof.
This is a clear image of new PVC roof balcony membrane (with railing installed) and temporary waterproofing at connection with flat roof.
This is a clear image of new PVC roof balcony membrane (with railing installed) and temporary waterproofing at connection with flat roof.
  Quotation Processed, July 30 2015:
  • Tie-in new DuraDek material to tar and gravel roof on both ends
  • Tie-in DuraDek material to tar and gravel roof and replace tar and gravel roof roundabout. Choose from EPDM, TPO, PVC, or 2-ply SBS torch-on
  • Main flat roof on top is not leaking and does not require repair or maintenance at this time.
  Click here for more information on our rooftop deck waterproofing and membranes. < End Report > Code: 14003 Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.

Photo Journal: Flat Roof Leak Inspection Edmonton AB, March 2014

Flat Roof Leak Inspection Edmonton - Below you will find a photo journal and emergency roof repair assessment from our Edmonton roofing repair crew at a commercial roofing site. Although the call began as a tar and gravel flat roof leak repair, the extent of damage escalated to the client requesting a quotation for flat roof recovery or replacement options. More field reports will be posted as they become available for this site. Regular Flat Roof Maintenance Will Save You Money. If you own a flat roof it is critical for you to conduct regular inspections, maintenance and repairs as needed. You will save considerable money if you do this twice per year. The reason it saves you money is that a complete flat roof replacement is expensive and 9 in 10 times had maintenance been done the replacement would not be required. If you do not do regular inspections and maintenance you could face a catastrophic failure which has occurred to this roof below. Simple spring and fall inspection and maintenance would have avoided a costly re-roof. Click here for a proper flat roof inspection and maintenance check-list. Emergency Flat Roof Inspection Edmonton, March 29 2014: Flat Roof Leaks. There are multiple large leak problems on this commercial tar and gravel flat roof that are currently being managed with buckets. Flat Roof Ponding. The roof assembly is carrying considerable ponding all over that is definitely a concern with dead weight load on the roof in times of sudden storms or in winter freeze thaw situations. Roof Drains. There are two drains on the roof that are useless; the previous contractors did not sump them properly. Roof Maintenance. Previous roof maintenance contractors did not remove the gravel before using tar to patch spots that needed repair. An excessive amount of tar has also allowed trapped air to cause blistering. Gum Boxes. Four gum boxes were actually near open water, and it was able to get into them. This is also contributing to some of the leaks. Roof Membrane. The tar and gravel roof membrane has become weather cracked from the sun, contributed by an improper ballast spread. If the pea gravel is not covering the bitumen layers the UV of the sun will dry out the bitumen causing it to crack and ultimately leak. Blisters. There is mass blistering of the roof membrane in multiple areas. If they continue, water will enter there as well. Several of the blisters on the roof are cratering water into them. Temporary Flat Roof Repairs. While we were on-site, we attempted to drain as much water as possible. The client called off the temporary repairs since the problems have become greater than simple roof maintenance work. The client has requested a quotation on roof replacement or recovery options.
Pitch pan pocket (gum box) is allowing water to enter. Needs maintenance.
Pitch pan pocket (gum box) is allowing water to enter. Needs maintenance.
Gum box needs to be filled.
Gum box needs to be filled.
Gum Box - Pitch Pan Pccket.
Gum Box.
Considerable roof ponding that was much worse prior to pumping water off roof.
Considerable roof ponding that was much worse prior to pumping water off roof.
Unit curb flashing is deficient and needs repair or replacement preferably.
Unit curb flashing is deficient and needs repair or replacement preferably.
Pea gravel is vacant on this section of roof allowing UV rays to dry out bitumen layers causing bitumen to crack and allow leaks in the building.
Pea gravel is vacant on this section of roof allowing UV rays to dry out bitumen layers causing bitumen to crack and allow leaks in the building.
Water ponding around flashing at curb of rooftop unit.
Water ponding around flashing at curb of rooftop unit.
Photo of tar and gravel roof showing all the rooftop units etc.
Photo of tar and gravel roof showing all the rooftop units etc.
Roofers vacuuming off water and using sump pumps to get water off roof.
Roofers vacuuming off water and using sump pumps to get water off roof.
Water ponding on Edmonton Tar and Gravel flat roof.
Water ponding on Edmonton Tar and Gravel flat roof.
Ponding water at various locations of flat roof.
Ponding water at various locations of flat roof.
Pea gravel on tar and gravel roof is vacant.
Pea gravel on tar and gravel roof is vacant.
Roof drain in bottom right of photo is not installed properly (it should be sumped down) to allow more water to get to drain.
Roof drain in bottom right of photo is not installed properly (it should be sumped down) to allow more water to get to drain.
Ponding everywhere on this flat roof.
Ponding everywhere on this flat roof.
Flat Roof Leak Inspection Edmonton
Flat Roof Leak Inspection Edmonton
Flat roof inspection reveals roof blisters at numerous locations.
Flat roof inspection reveals roof blisters at numerous locations.
20140329_181737 20140329_183548 20140329_183552 20140329_182107 20140329_182124 20140329_182204 20140329_182212 20140329_182234 20140329_182245 20140329_182249 20140329_182303 20140329_182308 20140329_182312 20140329_182336 20140329_182343 20140329_182354 20140329_182359 20140329_182413 20140329_182420 (1) 20140329_182424 (1) 20140329_182433 (1) 20140329_182439 20140329_182500 20140329_182505 20140329_182513 20140329_182653 20140329_182710 20140329_182713 < End Report > Code: 109 Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.

Ongoing Roof Leak Maintenance in Sherwood Park AB, May to July 2015

Assessment, May 7 2015: The site had a plumbing issue; the drain was backed up. Our client said if there were any roofing problems in the future, that they would definitely contact us. Surely enough, we received a call the next month. Scope of Work, June 1 2015: We are to locate and fix the leaks of a BUR roof and add one drain basket to the drain. When we got up to the roof, we had to locate two leaks which were both in the center of the roof but about 15 ft. away from each other. Once we swept all the gravel back, we noticed there had been two large gum patches that were previously installed by another contractor and had now failed. To test for failure, I pushed water out of the areas in the patch. We spudded both areas. One leak was 12 ft. x 1.5 ft. and the second was 10 ft. x 3 ft. Each tapered down to 1 ft. once both areas were spudded. Underneath, there were signs of water saturation, so we had to dry each area with a shop vac. Once dry, we then gave them a coat of asphalt prime to help the MASTIC bond on the BUR system. Once priming was complete, we then applied a coat of MASTIC to the entire system followed by a layer of reinforcement mesh. Another top coat of MASTIC was applied to seal in the mesh.
20150601_104710
We cleared gravel away from sections of the roof that we suspected water was entering through.
20150601_110050
Tears were found in some parts. We used SOPRAMASTIC to seal them in.
20150601_121144
Here is another exposed section which had been a tear running over a significant section of the roof.
20150601_115104
After spudding the tear, we applied mesh over top.
20150601_120319
A second coat of spudding was then applied over the mesh.
20150601_124628
We then let the second layer of spudding dry over the mesh.
Our second scope of work was to install a drain basket. Unfortunately, this could not be accomplished because it had been completely covered with MASTIC. There was nothing to fasten the basket to. Materials:
  • 25 ft. of 3ft. mesh
  • 3x pails of MASTIC roof patch
  • 1x can of spray primer
Followup - Installation Report, June 17 2015: After filling out safety documentation, we met with the client to go over leaks on the main roof when we had performed repairs on during the previous visit. From the client's assessment, there was still apparent leaking. A crew member went up on the roof and searched but could not finding anything. We will need to return when it is leaking actually occurs to get a better idea of where it is coming from. As for the roof above the restaurant, we tracked the leak to an air unit. Once we removed the metal, paper around the base was splitting and water was getting in, evidenced by moisture. We spudded the entire perimeter and applied a coat of MASTIC, followed by a layer of reinforcement mesh, and finally a top coat of MASTIC. We then reinstalled the metal and cleaned up the site.
20150601_104746
Second leak site, with a small tear on an exposed section of the roof.
20150601_105924
Moisture buildup underneath gravel.
20150601_124913
Redistributing gravel over the newly patched area. We followed a similar process as our first visit to address the section with the moisture buildup.
20150601_112813
Second leak site.
20150601_123059
Spudding and mesh being applied over the second leak site.
20150601_124629
Completed spud over the mesh.
Materials:
  • 2x pails of MASTIC
  • 25 ft. of 6 in. mesh
Quotation, June 23 2015:
  • SBS 2-ply patch along entire down-slope (60 ft. x 20 ft. patch)
  • Drain replacement with u-flows
Scope of Work: Remove all gravel in the area, spud out 10 ft. on either side of the drains, and 60 ft. down the low ride of the roof. Roll on asphalt primer and torch down the base. Add new drains with u-flows and cap the entire area. Materials:
  • 9x rolls of cap
  • 9x rolls of base
  • 10x gallons of asphalt primer
  • 2x 4 in. drains
  • 2x 4 in. U-flows
  • 2x pails of MASTIC
The client approved our quotation on the 25th of June:
Please go ahead with this job and let’s hope it solves our leaking issues.
Field Report, July 13 2015: We had our safety meeting and went up to the roof to shovel all the gravel away from the work-site and spudded the segments of interest in preparation of a patch. It started to rain and we had to call it a day.
IMAG0230
Arriving to the site
IMAG0231
We had to dry the area
IMAG0233_BURST002_COVER
Another view of the BUR system
IMAG0252
Entire site spudded
IMAG0255
Side view
IMAG0256
Ventilation system covered
Our crew had to delay work for the next few days due to heavy rain conditions.  July 17 2015: Preparatory work was completed today when we got the patch based in. A skeleton crew was left behind for fire watch. < End Report > More updates from this site will be posted as new field reports become available. Code: 33 Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.

Residential Roof Leak Repair in Edmonton AB, July 22 2015

Below you will find an initial assessment for an ongoing residential site by our Edmonton roofing repair crew. More reports will be posted as they become available. Initial Assessment, July 22 2015: We arrived on-site at 1:00 pm and were lead by the client to two leaks in the shop. One was coming from around the skylight, and another one around the chimney stack in the middle near the edge of the roof. Upon inspecting the roof top-side, we observed that the acrylic MASTIC around the chimney was cracking and lifting in areas. It should be removed and replaced with seam tape and liquid rubber. The penetrations require the same. It is only a matter of time until it begins to leak around the entire skylight. There are also cracks and splits in the skylight, which seems to have had been coated with spray foam. The metal gum box also needs to be topped off. There is a metal boot top-side as well that looks like it was only spray foamed. The roof measurements are 85 ft. long by 51 ft. wide, and the skylight was 4 ft. x 4 ft. It should take 25 man hours to clean and repair the penetrations, apply some gum patch into the metal boot, and cover the foam/top up the gum box with rubber MASTIC. < TO BE CONTINUED > Code: 154 Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.

Ongoing Roof Leak and Drain Repair in Fort Saskatchewan, July 2015

Below you will find an ongoing series of reports for a leak repair in Fort Saskatchewan, Alberta. The site is currently a work in progress. More updates will be posted as they become available. Scope of Work, July 21 2015: Upon arriving on-site, the client advised me about two leak sites - one in the kitchen and one above a light fixture by the washroom. On the roof, there was a major water ponding issue and lack of drainage. There is also a fryer vent that has major dripping onto the rubber. The grease that is leaking out has, over time, started to eat away at it [the rubber]. Structural integrity has been lost, so the next step is to cut out the damaged area and replace it with a 12 ft. x 12 ft. EPDM fixture. The next scope of work would be to install an internal drain, piped in by a plumber. < End Report > Code: 100 Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.  

Roof Leak Repair in Edmonton AB, December 2014 and July 2015

Below you will find an assessment and field report from the Edmonton roof leak repair crew for a residential client. The roof had been experiencing leaks on two occasions due to a lack of proper ventilation and insulation. Assessment, December 12 2014: By the time we had arrived, the leaking had stopped. However, our client still had buckets out in her kitchen for water collection. The client also showed me the garage, where there appeared to be water damaged on the ceiling. Again, no evident leaking at the time of assessment. A roof inspection was also completed, and we found 4 in. of ice damming.
20141211_140350_resized
Water collection in kitchen
20141211_140354_resized
Interior assessment
20141211_140507_resized
Garage assessment
20141211_141257_resized
Ice damming
20141211_141540_resized
First leak site
20141211_142207_resized
Second leak site
  Installation, July 20 2015: When I arrived on-site, the client showed me two leaks. One was in the living room and another in a bedroom. Both leaks were in line with each other. On the roof, a crack running half the length of the roof was found - the same cracked that was fixed the year before. The crack had probably reoccurred due to a lack of insulation and venting. We fixed the crack again with LR and the client was notified about the insulation and ventilation.
20150718_121643
Crack running the roof length
20150718_121649
Reoccurring crack
20150718_121726
Flooding the area
20150718_123607
LR repair
20150718_123620
LR, post-application
  < End Report > Code: 6407 Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.

Commercial Roof Recovery for Existing Client in Edmonton AB, April to June 2015

Below you will find a series of quotations for an existing commercial client. We had previously dealt with some leaks for them as outlined here. This time, the client required a roof recovery for a 28 ft. x 44 ft. garage. Client files request, April 20 2015:
I know that you quoted on the small garage, we would like another quote that requires the following: layout, retrofit, TPO roof, no asphalt.
Quotation, April 20 2015:
  • Layover, remove stone.
  • Install new 2 in. polyisocyanurate and 0.45 mm TPO membrane.
  • New flashing is required all around to match the front of the building.
Assessment, June 22 2015: We arrived at 8:00 am and searched for roof leaks around the unit for two hours. With no luck, there was still the remaining task of installing the last drain unit over another one of the units which needed work. The roof on the second building is a 28 ft. x 44 ft. BUR roof on a wood deck that leaks in too many places to fix. One drain on the northwest corner and three other penetrations, as well as two vents and a motor exhaust are going through the roof. There is a 4 in. wood detail around the edge and one scupper. We suggest an EPDM roof recovery. The maintenance manager for the site also gave us a call to tell us that a leak was found on the west wall of the building. The crew found numerous rips in the roof along the membrane; it had been completely separated from the drain.

Materials:

  • 5 ft. of cap
  • 5 ft. of base
  • 1x can of spray primer
  • 1x 3 in. drain
  • 1 can of mastic
  • 1x roll of 6 in. reinforcement mesh
New quotation based on assessment, June 22 2015:
  • Gum patches to three or more areas
  • Replace the drain with a new 3 in. unit
  • Roof replacement using an SBS 2 ply system
  • Estimated time: 20 hours
< End Report > Code: 128 Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.

Flat Roof Drain Repair Edmonton, January 23, 2015

Below you will find a report from the flat roof repair crew in Edmonton Alberta conducting their report and repairs. A material list is also made available, as specified in the crew's report. When I got to the site, I confirmed what the crew had thought: the drain had a hole punched through it and was leaking back into the system. The site supervisor went to pick up the required supplies and we worked on removing water in the area. Once he got back, we installed the retro-drain with a proper U-Flow® Mechanical Seal and tied it back into the torch on the roof.
  • Materials Used: 1x roll of cap 1x roll of base 1x20 lb. bottle of propane 1x can of spray primer 1x pail of SOPROMASTIC 1x U-Flow® Mechanical Seal 1x Retro-Drain with Drain Screen
< End Report > Code: 106 Post topics: Flat Roof Drain Repair Edmonton, Alberta.   CONTACT US Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton, Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.

Flat Roof Leak Repair Edmonton, January 22 2015.

Below you will find a report from the Edmonton roof repair crew for a commercial car wash roof located in Sherwood Park. There had been a flat roof leak. I met the crew on-site and went up to the car wash roof, where I found water was pouring through a curb on the concrete deck. I checked the curbs in the area leaking and found nothing. Then, I expanded the search and found an anchor installed through the roof membrane that was improperly sealed off. I installed a lick of gum over the problem area and asked the client to call me back if the problem persisted. Please note that this is only a temporary repair and we should return to check if the improper sealing was actually the cause of the leak. < End Report > Code: 2000 Contact Us Call our 24 hour emergency roof repair at 1.780.424.7663. Mail to: 3428 99 Street NW Edmonton,  Alberta T6E-5X5. We service all of Alberta including Edmonton, Stony Plain, Spruce Grove, Fort Saskatchewan, St  Albert, Sherwood Park, Leduc, Nisku, Beaumont, Lac La Biche, Grande Prairie, High Level, Westlock, Slave Lake, Edson, Drayton Valley, Devon, Camrose, Wetaskiwin, Tofield, Lamont, Morinville, Vegreville, Tofield, Millet, Calmar, Evansburg, Redwater, Onaway, Viking, Athabasca, High Prairie, Valleyview, Fairview, Peace River, Whitecourt, Mayerthorpe and many more rural areas and towns.